Volvo AWD 850 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 10/2019 850 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

Mysterious Front End Ratlle on my 1995 850 - Ideas?? 850

posted by  someone claiming to be GNB on  Thu Mar 31 19:29 CST 2005 [RELATED]

I have been hearing a loose sorta rattling noise apparently from the front passenger side.

I replaced the sway bar links and the rattle is still there.

It is not a constant noise and is not a clunking sound like when my spring seats broke. It just a slight enough rattle to bother you when driving with the windows down and radio off.

I have checked under hood to see if anything is loose and cannot find a problem.

Suspension is firm, good koni struts.

Possibilities: Strut mounts ? Spring Seats ( doubtfull)?







  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Mysterious Front End Ratlle on my 1995 850 - Ideas?? 850

    posted by  sblckwd on  Sat Apr 2 14:16 CST 2005
    Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
    last visit: Fri Feb 5 09:59 CST 2010
    [RELATED]

    Check the 2 bolts that attach the A arm to the sub frame. Use a wrench. If they are loose you will get a "clicking/rattle" sound. 15mm and 18mm








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Mysterious Front End Ratlle on my 1995 850 - Ideas?? 850

    posted by  ahles5 on  Fri Apr 1 03:51 CST 2005
    Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
    last visit: Fri Jun 8 04:35 CST 2007
    [RELATED]

    How about sway bar bushings or engine mounts. I know I had a rattle that bothered me on 93 and found out the sway bar bushing were worn out. New bushings, no problem. Engine mounts ar possible as well. AT is very close to frame on drivers side. bad mounts can cause a contact point to develop.








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    Mysterious Front End Ratlle on my 1995 850 - Ideas?? 850

    posted by  someone claiming to be ksg on  Fri Apr 1 03:00 CST 2005 [RELATED]

    Are the pad retaining springs and all shims in place on the brake calipers? Are any of the caliper bolts loose? Also if any work was done requiring removing the plastic splash guards or air dams (timing belt, radiator hoses, control arm, etc.) are the guards intact (not cracked) and were they put back tightly with all their fasteners?








    •   REPLY TO THIS MESSAGE    PRINT   SAVE 

      Mysterious Front End Ratlle on my 1995 850 - Ideas?? 850

      posted by  ocotillo on  Fri Apr 1 12:55 CST 2005
      Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

      the heat shield was loose on my 94 850T and a lot of other things I realize from 11 years of driving. Nothing serious just that alot of screws that hold body parts get loose over time.







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.