Volvo AWD 850 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 5/2010 850 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Fault mode for coolant tank pressure cap? 850 1994

posted by  dwc on  Fri Dec 17 17:13 CST 2004
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Thu Jun 14 04:22 CST 2001
[RELATED]

Hi Group:

Is there a "typical" fault mode for the coolant tank pressure cap? I ask because last week our '94 850 Turbo boiled over for no reason I've been able to find. My wife had the car, and didn't think to look at the temp gauge, but the coolant level was probably too low after it boiled over. The thermostat checks OK, but I replaced it anyway, the temp sensor was OK, but I also replaced that, and the fan circuits and fan work as they should. My only guess is that the relatively new pressure cap (~16 mos, ~10K miles) suddenly allowed the system to depressurize. About 1/2 gallon of coolant was lost, and the car was towed home, but now that it's back on the road all seems OK.

Is there a better cap available than the OEM Volvo (green)? I've seen on a few autoparts vendor sites that a Stant cap is available, but in pictures it looks identical to the OEM. Is it different, or just a re-boxed OEM?

Thanks in advance,

Dean





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Fault mode for coolant tank pressure cap? [850][1994]
posted by  dwc  on Fri Dec 17 17:13 CST 2004 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.