Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 11/2011 200 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Plug at rear of valve cover.... 200 85

I've got a PVC problem. My 1985 240 - 166K keeps popping the plastic plug at the back of the valve cover. It never comes completely off so I don't loss any oil. But now I check it all the time and snap it back into place.

I've been good about changing the flame trap and oil trap box.....What else should I be checking??? No performance problems...

John








  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Re: Plug at rear of valve cover.... 200 85

John --

If that plug is popping out, it almost certainly means you have positive pressure in the crankcase.

A way to check this is with the "jiggle" test. Loosen the oil filler cap, but leave it sitting in place with the engine idling. If you have positive pressure, the cap will jounce and bounce and jiggle around from the idling engine. But if you have appropriate crankcase vacuum, the cap will be pulled down and won't jiggle.

If you still have positive crankcase pressure, it probably means you've missed the small vacuum hose (easy to do, I did on my '86). The flame trap housing has a third small vacuum line that frequently plugs rock-hard solid. Replace it. Also check the fitting in the intake manifold the hose connects to -- it often plugs, and must be reamed out.

A good trick is to fasten a strap across the plug. On either side of the hole is a bolthole -- 6mm, I think -- used to mount the distributor when that engine is installed in a 700. You can fabricate a strap across the plug secured at each end by bolts (I did exactly this). IPD now sells an adapter for this.

But be aware that if you have crankcase pressure, you run the risk of additional problems. Engine seals and gaskets may be seeping, and on rare occasions you can pop a seal out of its housing. A popped rear main seal is a much bigger headache than that plug.









  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Re: Plug at rear of valve cover.... 200 85

replace plug (and valve cover gasket)...they sometimes loose their shape

and not fit right after they fall out

jv







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.