Volvo RWD Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 2/2004

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

1981 GL (240) ((MANUAL)) can't get car in gear, please help

1981 GL (240) manual 4-speed with overdrive - had a problem a few nights ago with overdrive, it would work but you would hear a loud moaning noise from under the hood. now, the car cannot get into gear at all. it started sporadically over the past few days and has gotten progressively worse to now, where i can't get it into gear. from a dead stop, you will try to put it in first and drive away, but the wheels don't move at all. it seems like it just can't get in gear at all. the noise coming from under the hood is like a moaning or really soft scraping. when you put it in first, it makes this noise and it sounds like it's whirring or spinning. when you try to put it in second gear, it does the same, except the whirring or spinning noise is twice as fast. when i rev the engine, the rpm meter doesn't seem to do anything out of the ordinary. about a week ago or so, someone bumped me really good from the front while they were parallel parking. a vacuum hose came right off after this and i had to put it back on to start the car. i am thinking that the two are also possibly related, in that the impact could have messed a mount or bracket up so that things are not properly engaging now. the car has 107k miles, so although it's an '81, I have not had transmission-type problems before and i think it's too few miles for _everything_ to be failing now all at once.

Please help if you have seen this before or know what it may be...








  •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

    1981 GL (240) ((MANUAL)) can't get car in gear, please help

    You didn't mention how the clutch was working. Did it feel like you had pressure when you pushed down? It's possible the clutch is bad and just slipping. Check you rear transmission mount. If that lets go you can't put the transmission is 2nd or 4th.

    If it is the clutch new replace the throw out bearing when you change the clutches








    •   REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

      1981 GL (240) ((MANUAL)) can't get car in gear, please help

      the clutch appears to be working. there is pressure just like normally when i push it down. when i throw the gearshift into first, it's as if two points aren't meeting and the car does not go into gear. when i try to put it into gear with the shifter, that's when i hear the whirring noise and can't get it in gear.

      i am still going with some kind of mount theory. could this just be a bad bearing somewhere?







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.