Volvo RWD 700 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 2/2004 700 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

A/C question, evaporator or orifice? 700 1990

posted by  orie on  Thu Aug 7 08:11 CST 2008
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Sun Feb 12 17:02 CST 2012
[RELATED]

The A/C on my 745Ti hasn't worked since I bought it. But I have moved to a hot area, and wish for it to work again. So, I knew my low side had a low pressure (about 18lbs of R12). Added a bit to bring it up to charge, compressor started cycling as normal.

Now, when the compressor kicks on, you hear a hiss in the dash which gets louder as the compressor runs, then the compressor kicks off after about 10 seconds and the hissing fades away. Then a few seconds later, the compressor kicks on again, and the hiss returns. That cycle continues. This hissing can only be heard from the cabin. Is this clearly a leak in the evaporator? The low side holding pressure indicates that it's definitely a leak in the high side, right? Perhaps this is the orifice? I'm going to DIY the repair, so no, a shop is out of the question (I WILL have the R12 removed and the system vacuumed by a shop though).

The air is warm and the low side pressure is ok.

Thanks!






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New A/C question, evaporator or orifice? [700][1990]
posted by  orie  on Thu Aug 7 08:11 CST 2008 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.