Volvo RWD 700 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 3/2005 700 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Hesitation while driving 700 1987

posted by  EPS on  Tue May 28 06:36 CST 2002
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

I think I finally found the cause of hesitation/ Bucking problem. FYI brickboarders. On Turbo Models check that the waste gate linkage is in place. I found out by accident while repairing an oil leak at the oil cooler flange "donut", that I could see the wastegate linkage off the wastegate pin. Therefore the waste gate was flapping back and forth aimlessly.

You look up at the turbo from underneath and make sure that the linkage is in place on the waste gate lever pin. If your clevis pin has rusted out, like mine did, the linkage will fall off the pin and not control the wastegate properly.

I read somewhere that there is a fuel cut-off to the fuel pump at overboost, to prevent engine damage and I believe this is what was happenning to my car. I should have noticed the bad acceleration also but I do not abuse this car because it is somewhat older.

Hopes this helps others.



1987 745Ti, 299,400 kms, M46, Toronto, Ont (for sale)






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Hesitation while driving [700][1987]
posted by  EPS  on Tue May 28 06:36 CST 2002 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.