Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 5/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Engine cuts out at a particular RPM. 200 1989

posted by  240bill on  Sun Mar 2 08:34 CST 2003
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

First time post. Thanks in advance!

Intermittent problem:

My 89 240DL wagon engine cuts out at what appears to be a particular RPM. It does so regardless of vechicle speed or gear. Without changing throttle position the 245 slows as does the RPM and then the engine begins to pull again untill it reaches that consistant, but unkown RPM.

When the problem is present:
Vechicle at a stop, in neutral (manual), holding the accelerator steady. The engine will "rev up" until it hits the magical RPM and then cuts out until it slows down and it will pick back up. It will continue to cycle regardless of humidity and temp.

Starting off in 1st, the 245 will "buck" as the engines revs up and down, cutting out and in. If I upshift (lowering the RPM's) the cutting out and in cycle continues but, is lengthened.

REF only: unkown if related.
Fuel pump relay was replaced.
Fuses checked.
Check eng. light on.
No codes present at "diag module", but led works when 12v is applied.
additional braided ground added between chassis and engine.

Thanks, 240Bill





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Engine cuts out at a particular RPM. [200][1989]
posted by  240bill  on Sun Mar 2 08:34 CST 2003 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.