Volvo RWD 700 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 11/2001 700 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Headlight Relay Relocation? 700 1987

Problem: The headlight relay on my 740 wagon overheated (fatally) a few days back, taking with it the fuse socket. The problem is mentioned in the FAQ, and there is a solution, *however* the Volvo dealership is unable to get the parts in until thursday, and I may need to drive beyond daylight hours in the very near future. I've been doing quick junkyard hunts for parts, but I've only been able to find overpriced beginning-to-be-damaged pieces or unusable relay sockets in a condition similar to mine, all of which are priced way too high ($45 for a *socket and relay*? No thank you). If I can get back home, I could hit up a local junkyard with known good parts and pick up some goodies, but until then, I'm looking for a good old fashioned "dangerous and ugly, but it'll do the job" solution. If I use this, it'll only be on for one or two days for (at the most) three hours. In addition to this, I have my aftermarket fog lights wired into the parking lights (which illuminate pretty well, actually), but I still lack high-beams (though, I have a pair of driving lights I'm about to install just in case and a funky fog/driving/both switch to act as the high/low switcher in case I desperately need lighting). But enough babbling...

The idea: Could I make an extension harness with individual connectors that would connect to the free-floating points in the socket to those on the relay through a 12-18" length of 12/10 gauge wire? Would this be safe, or should I attempt to use larger wire? I am under the impression that the entire current of my car's headlight system is being run through this one relay socket, so I'd like to avoid any potential melting/arcing problems for the very short time this will be used. suggestions are damned well appreciated!
--
1980 240DL, 1984 240DL, 1988 740GLE, 1993 850 GLT






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Headlight Relay Relocation? [700][1987]
posted by  Sanfam  on Sat Dec 18 19:15 CST 2004 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.