Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 10/2002 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Throttle body really gunky, FT dirty too. Causing high NOx? 200

posted by  someone claiming to be Ron Anderson on  Sat Feb 5 09:38 CST 2005 [RELATED]

Hi,

My 1989 244 DL (160000 k) just flunked the low speed NOx test, so i am fixing/cleaning some things on the engine. The car passed all the other tests fine, but had almost double the allowable NOx reading at the low (15mph) test.


I cleaned out the Flame Trap because it was not totally cloged but getting that way. Had to use a drill to clear out the fitting on the side (Thanks FAQs!).
I then decided to clean the TB and found it covered it grime and oil. I have tried to attach a picture of it before i cleaned it.

Does this seem normal? There was even gunk/oil inside that flex tube that attaches to the Throttle Body.


I have only had this car a few months, so this is the first time i have had to get it smog checked. The gas mileage is a little disapointing (about 22), but it seems to run great. If any of the experienced Volvo guys out there know what the main cause of high NOx at low speeds is, i would really appreaciate any advice at all.


Thanks,

Ron





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Throttle body really gunky, FT dirty too. Causing high NOx? [200]
posted by  someone claiming to be Ron Anderson  on Sat Feb 5 09:38 CST 2005 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.