Volvo AWD S60 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 9/2021 S60 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

2004 S60 FWD Fuel Pressure Problems...Help! S60 2004

posted by  The Tenor Man on  Mon Dec 5 09:19 CST 2011
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Wed Dec 7 12:19 CST 2011
[RELATED]

Hello,

I'm new to the Volvo S60. This one has about 95,000 miles on it.

The dealer has just replaced the Fuel Pressure Sensor under recall. The problem was surging and stalling. The new Sensor didn't solve the problem.

I connected my code scanner and the fuel pressure is jumping all over the map. It goes as low as 5lbs. when driving (car jerks) and as high as 78lbs. and also throws a fuel pressure sensor code.

The mystery is that after about 30 minutes of driving, the car settles down and runs fine. The fuel pressure stays at about 54-55 lbs. I've erased the code and it doesn't return until the next day when the engine is cold when the problem starts all over again.

Could this be a loose wire on the fuel pump, a bad fuel pump or a bad fuel pressure sensor?

Any help would be greatly appreciated...many thanks in advance.

The Tenor Man






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New 2004 S60 FWD Fuel Pressure Problems...Help! [S60][2004]
posted by  The Tenor Man  on Mon Dec 5 09:19 CST 2011 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.