Volvo RWD 900 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 4/2004 900 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

iac controller 900 1993

Hi,

Firstly check the onboard diagnostic (OBD) for any error code. This could give a hint as to what the current issue is.

See:
https://www.brickboard.com/FAQ/700-900/EngineOBDCodes.htm


Secondly you could check if your throttle position switch (TPS) is behaving properly. The TPS is a black squarish thing (about matchbox size) with 3 wires connected to it. Its located at your throttle body. The TPS takes care of your engine idling when foot is off the throttle. Normally any issue with TPS is reported as error code by the OBD. In short your TPS might need some adjusting.

Thirdly about the MAF you could clean its platinum wire and temp sensor inside with a MAF cleaner. I usually use carb cleaner anyway. MAF cleaner is more gentle acting chemical than the carb cleaner but so far I have no issue with mine. Use a hairdryer to quickly evaporate the chemicals off.

Lastly check your spark plugs. Worn plugs with increased gap may also lead to idle issues.

Try these first and report back.

Regards,
Amarin.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New iac controller [900][1993]
posted by  pierso  on Fri Jan 15 14:38 CST 2016 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.