Volvo RWD 200 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 6/2002 200 INDEX

[<<]  [>>]


THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD




  REPLY TO THIS MESSAGE    PRINT   SAVE 

small white box hanging from passenger side under dash- something to do with fuel? 200

I've been trying to get my old 85 240 running again for a while now, I think I'm almost there, and I think my problem might have something to do with this little white box. it says VOLVO on the top, 12V, made in germany, and some parts numbers.written on the front in black sharpy is "86 volvo fuel" is this something to do with the fule injection? when I'm starting the car, sometimes it works, and sometimes I just get a nasty screeching noise , and vibration from the box. I unplugged it from the 6 prong female connector, and popped the box open, some of the circuit board looks a bit corroded. is this a piece I can pick up somewhere? what does it do? thanks








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    small white box hanging from passenger side under dash- something to do with fuel? 200

    Common enough problem. About 2X1 inch white box? Mmm hmm, that's your fuel pump relay. Part number on newer ones and replacements is 3523608. Older ones can have a different number.

    Make sure when you replace it, you clip it to something, so it doesn't get water in it again- that's likely what happened to that one. Been there twice with a friend's 87. The second time, I realized water was dripping from the wiper motor hole and filling the relay up, burning it out.

    They're supposed to be clipped right to the firewall. You can tie them up to the other wires or whatever.

    Grab one from any 85-93 240, any 740 gas engine, any 940. The 7s and 9s keep them in the center of the dash, front of the fusebox. All 240s have them in the same place. I always carry a spare in the glovebox.

    While you're at it, replace your 25A fuse holder under the hood, right behind the battery. It feeds that relay, and for $3 it's cheap insurance against a breakdown.
    --
    Rob Bareiss, New London CT ::: '87 244DL/M47- 234K, '82 245T/M46-182K, '84 242DL/AW70-100K, '89 244DL/AW70- 212K and I miss my: 86 244DL 215K, 87 244DL 239K, 88 744GLE 233K, 88 244GL 147K, 91 244 183K








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    small white box hanging from passenger side under dash- something to do with fuel? 200

    That's your fuel pump relay. Yep, you need one, and they are available from the online parts sources and used at the scrap yards. Check the 700/900 FAQ at the top of the page under features,for some suggestions and tips to repair yours.
    --
    '94 940 150k, '86 240 170k, '72 142 KIA, '70 144 KIA, '69 144 RIP








  •   REPLY TO THIS MESSAGE    PRINT   SAVE 

    small white box hanging from passenger side under dash- something to do with fuel? 200

    hi fuel pump relay, look closely with magnifing glass, i use jewelers loupe. you can see the cracks in the solder joints. heat em up and re-run the solder. also if possible make sure the connectors are tight when the relay is plugged back in. or buy a new one. good luck







<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.