Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 11/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Carbon Brushes in Alternator 200 1991

This problem has been addressed in other threads.
I had the classic "dash idiot lights flicker on and off dimly during driving" problem at 370,000km. Barely 12 volt at the battery. I changed the rectifier/brush assembly in the Alternator. The one I bought was adjustable so I installed it cranked it to 14.2V at the battery and life is good. On engine install is handy too.

This week it starts again. 420,000km. Barely 12 volt at battery so i again yank the rec out and the brushes are worn. The lower brush is almost entirely worn and has signs of intermittent contact. (rough unpolished sections on the face of the brush rather than the glass like shine. but otherwise good.
My questions is left expectancy. I expected more than 50,000kms out of the replacement I installed. Thoughts anyone?
Commutator is smooth. no lips or ridges.
Bearings are good. No play.
Length of OEM brushes VS aftermarket?
--
400,000KM and still ticking






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Carbon Brushes in Alternator [200][1991]
posted by  Kenner  on Thu Dec 27 07:37 CST 2007 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.