Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 2/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Moving to where I have to pass emissions testing A little advice please...... 200

posted by  Stickbuilder on  Sat Nov 27 08:39 CST 2010
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Fri Oct 24 03:31 CST 2014
[RELATED]

I'm in the process of moving to the Nashville area. Anyone living in Metro Nashville and the surrounding counties must pass an emissions test prior to tag issue every year. Helga used to pass with flying colors, but she has not undergone an emissions test for nearly 6 years. Here is what I have done in anticipation of the test. Please tell me if I missed anything.

Cleaned Throttle body, and adjusted TPS.
Replaced Idle air valve.
Cleaned AMM.
New Plugs, Cap, Rotor and Wires, Ignition timing set to 12 degrees BTDC.
New main fuel pump and filter.
Adjusted mixture on AMM (LH 2.2 system) to where the needle on the dwell meter pulses between 15 and 70 degrees.
New air filter
New downpipe and Catalytic converter gaskets
New thermostat in air filter housing
New air filter.
Seafoamed the upper end of the engine.

Thanks, Bill





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Moving to where I have to pass emissions testing A little advice please...... [200]
posted by  Stickbuilder subscriber  on Sat Nov 27 08:39 CST 2010 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.