Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 8/2002 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Starla Cat Converter Plug--Lost! Any suggestions? 200 1987

posted by  kourt99 on  Thu Aug 29 09:39 CST 2002
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Mon Oct 13 10:58 CST 2014
[RELATED]

I have an 87 245. I recently replced my old rattly catalytic converter with a new Starla cat from FCPGroton. It went on well, without problems. The cat has two ports on it, presumably for oxygen sensors or something like that. Both of the ports were plugged with large screw-type plugs (I think).

Today, while driving, the sound of my exhaust suddenly became very loud. I stopped and looked under the car, at the cat, where the noise was coming from. The plug on the driver side had popped out! Now, hot gases and lots of nasty noise are coming from that hole.

Has anyone experienced this before? Any basic suggestions on how to replace this or where to find a replacement? I will likely measure the hole and try to find a suitable fastener, but barring that I will have to take it to a muffler shop and have them stick something on it. I would like to avoid going to a shop to fix this. Any ideas are welcome.

kourt
87 245
Austin, TX






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Starla Cat Converter Plug--Lost! Any suggestions? [200][1987]
posted by  kourt99 subscriber  on Thu Aug 29 09:39 CST 2002 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.