Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 7/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Cold start problem....at my wits end 200 1989

posted by  Big Joe on  Mon Dec 23 17:38 CST 2002
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Sun Jan 16 08:29 CST 2011
[RELATED]

Hello all,

I can't seem to figure out this cold start problem. Could it be this air box thermostat I 've been hearing about. Here's what I have done to date. I don't know what else to do. It starts better in the garage ( where its warmer). It has gotten progressively worse.


- AMM is ok car has been tested with other functional units with no difference
- RPM sensor
- Temperature Sensor
- Fuel Pump relay replaced with no difference ( date stamp 1994)
- In-tank sender unit with pump
- Fuel filter and check valve on main pump
- Plug wires and coil wire
- Used alternator
- New voltage regulator
- Used starter
- New oil trap
- Battery 2 years old tested – good
- A good spark is produced when engine is turned over
- swaped out the coil with a spare
- swapped out the main computer with a spare
- new fuel presure regulator
- new fuse and fuse holder

General maintenance up to date
- Spark plugs
- Rotor and cap
- Air filter
- Required fluid changes
- PCV system cleaned
- Throttle body cleaned





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Cold start problem....at my wits end [200][1989]
posted by  Big Joe  on Mon Dec 23 17:38 CST 2002 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.