Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 6/2005 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

AW70 fluid leak from OD solenoid 200 1983

posted by  Brick Head on  Sat Jan 18 11:57 CST 2003
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Sun Mar 31 19:45 CST 2013
[RELATED]

I've got a severe transmission fluid leak (8 inch wet puddle every morning). Of course I top it up but adding 2 quarts a week is a sign that there might be little problem - not to mention the slick driveway!

Anyway, I put the Silver Bullet up on the ramps and found the leak originating from the OD solenoid valve. This unit is about 9 months old. Thinking the O-rings must be shot I took it apart to check them - the O-rings were well seated and are in good condition. Since I can't get new O-rings today anyway I put it all back together hoping to get lucky.

After starting it back up, I noticed the leak is actually coming from under the rubber cap at the top of the solenoid valve. I pulled the cap up to verify this.

The Bentley manual doesn't show any other seals in the valve assembly. Is it new valve assembly time again?

Thanks,
Curt






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New AW70 fluid leak from OD solenoid [200][1983]
posted by  Brick Head  on Sat Jan 18 11:57 CST 2003 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.