Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 12/2006 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

OD relay problems 200

posted by  someone claiming to be sweet_volvo_honey on  Mon May 24 10:05 CST 2004 [RELATED]

Hey yall,

Ive been having trouble with the OD relay in my 240 dl wagon. I replaced it several times. Each time I did, it would work for a short time then go bad.

We'll after all this I pulled all the old relays out to have a look at them.
Took the case/cover off all of them, and inspected the circuit boards.
It turns out that on each of them there was a solderline that looked as if melted in two, like a fuse that burnt out. this little solder connection is near the edge of the board and very near the numbers 86 and 87 stamped on the housing.

Dad and I resoldered this junction and things seemed to work fine....for a short while until it burned out again.

does anyone know why this keeps burning out? any fixes out there?

kisses,
Sweet Volvo Honey






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New OD relay problems [200]
posted by  someone claiming to be sweet_volvo_honey  on Mon May 24 10:05 CST 2004 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.