Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 5/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

AC Woes - Compressor does not turn on 200 1984

posted by  RichardL on  Mon Jul 12 05:54 CST 2004
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

I don't have a wiring diagram so I'm working in the dark here. We have a 1984 240 Sedan. The AC was working, but now is not. The clutch is not engaging. I checked the low pressure port, it is about 44lbs give or take a little (cheap gauge). I tried bypassing the low pressure cut out, no change. If I hook the compressor clutch coil directly up to power the clutch engages and the compressor spins. I did not leave it on long enough to tell if it would put out cold air, however the larger outlet pipe got very toasty to the touch in the short time I left it on. The low pressure port may have gone up a pound or two, but no significant change.

I'm looking for assistance on tracking down the issue. Good places to start, and any idea on where I might find an electronic copy of the wiring diagram would be greatly appreciated.

Thanks!

Rich






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New AC Woes - Compressor does not turn on [200][1984]
posted by  RichardL  on Mon Jul 12 05:54 CST 2004 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.