Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 4/2003 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Yikes!! Wiring troubles. 200 1982

posted by  82-242-GLT on  Mon Nov 1 05:55 CST 2004
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

I'm sure many of you have been through this before but here's my story. Last Thursday morning the upper heater hose split just under the intake manifold. Lots of steam but got her home before all of the coolant was gone. Never went over 3/4 on the temp gauge (whew)

On Sunday morning I grabbed some 5/8" hose and went at it! (I'll get the proper hose ASAP, just a bodge with the straight hose so I can use the car Monday morning)

As I was moving things out of the way to get under there (what a nasty place to reach BTW) I attempted to unplug the engine wiring harness. You folks that have been around 80s bricks know what I found!!



Luckily I had some shrinkwrap and there was good insulation below the mess. Here's the finished job.



I think I'm going to pull the adhesive electrical tape off and do a better job of sealing things up as soon as I get a chance.

Where else should I look for damage?

Mark.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Yikes!! Wiring troubles. [200][1982]
posted by  82-242-GLT  on Mon Nov 1 05:55 CST 2004 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.