Volvo RWD Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 5/2003

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

overheating 240 1990

posted by  confused_chris on  Wed Jun 29 03:10 CST 2005
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

So here's the story.

My 1990 240 DL is overheating into the red. This usally starts after freeway driving several miles at about 60mph, or spending 20-30 minutes on city streets. Turning on the heat and driving moderately (45-50mph)solves the problem. Once it has started overheating on the freeway, it gets worse when I get stuck in stop-and-go.

The fan spins freely while hot, but has resistance while cold, so I'm assuming that the clutch is bad. My question is, since the car doesn't really cool down while driving at freeway speeds, is the fan clutch my only problem? Or do I need to look farther? Could these symptoms be a combination of fan clutch, dirty radiator, bad thermostat, or water pump? The coolant level is full, and if there is a leak it's a very slow one.

Thanks for the advice.

-Chris





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New overheating 240 [1990]
posted by  confused_chris  on Wed Jun 29 03:10 CST 2005 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.