Volvo RWD 700 Forum

INDEX FOR 10/2025(CURRENT) INDEX FOR 6/2004 700 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

1991 740: Window blocks 700 1991

As the window starts down or up does it tip so the top is no longer horizontal? The driver's window on our 1991 745 did just that. The window would not close at the top without a helping hand on the lower end. I installed a mechanism from a low miles parts car that I assumed would fix the problem but it didn't.

I ended up taking apart the door enough to get at the seal on the front side of the window. The window glass had to be removed to get at the full length of the seal. I pulled the seal out of it's channel. I cut a piece of cedar that was as wide as the channel and about 3/32" thick. I put the cedar in the full length of the channel and then pushed the seal back into place. In effect it made the window opening 3/32" smaller. With a closer fit to the glass it was prevented from tipping.

Randy
--
Any twenty minute job is just a broken bolt away from a three day ordeal






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New 1991 740: Window blocks [700][1991]
posted by  greg_mustang  on Sun Sep 3 19:14 CST 2023 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.