Volvo RWD 700 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 5/2002 700 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

A/C condenser replacement 700 1992

posted by  someone claiming to be ringlee on  Thu May 2 07:15 CST 2002 [RELATED]

To replace the condenser in a 90+:
-Remove grill, top grill cover panel, and upper radiator support member
-Remove the front air baffle, air filter intake and sensor connectors to condenser
-Remove bottom air baffle between spoiler and radiator bottom
-Disconnect condenser
-Remove by lifting straight up (careful of chrome!) and once removed, measure the oil that drains out the old one if any
-Remove pressostat sensors
-Install foam rubber seals on new condenser (remove from old) and rubber bushings on bottom and/or top
-Reinstall using new o-rings coated with correct compressor oil
-Torques: to condenser: 25 Nm (18.4 ft-lb)
from condenser: 20 Nm (14.8 ft-lb)
-Reinstall other parts and connectors and recharge system. If you had a leak leading to discharge, then convert to R134. Install the correct amount of oil.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New A/C condenser replacement [700][1992]
posted by  djtibb subscriber  on Thu May 2 03:45 CST 2002 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.