Volvo RWD Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 11/2003

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

rattle near CAT

posted by  Bram Smits on  Sat Mar 1 13:24 CST 2003
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

Rattle on letting go of the gas _could_ indicate busted cat internals (new ones are only about $125 plus shipping from the online places), but before you do that check:

- heatshields
- bracket holding the downpipe to the block/transmission. These often rust off (either the bolt or bits of the bracket on the downpipe), and can cause lots of annoying rattling. I consider it a non-essential part, so if it's bad I tend to solve the problem with an angle grinder applied to the offending bits of downpipe bracket.
- and on a 940 I just fixed there was, for a reason I haven't been able to fathom, a loose hoseclamp sliding up and down the downpipe rattling its little heart out. I'm not sure what previous bodge that used to be a part of, but removal solved the problem.

Bram






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New rattle near CAT
posted by  Survivor99  on Sat Mar 1 11:21 CST 2003 >
  • New rattle near CAT
    posted by  Survivor99  on Sat Mar 1 16:02 CST 2003 >
    • New rattle near CAT
      posted by  someone claiming to be MittenHed  on Sat Mar 1 17:12 CST 2003 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.