Volvo RWD 900 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 1/2002 900 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

weeping leak of coolant on top of water pump,, 900 1993

I have changed out the gasket and seals on these red block water pumps more often than I would like to admit. It is just a bad design. On the bright side it has never been because of a catastrophic failure or a resulting low level of coolant. They just start to leak and continue until addressed.

I raise the hoods on our cars quite often to check fluid levels and generally take a minute of poking around looking for what might be amiss. I also have a low coolant sensor circuit on all the cars and that increases my comfort level.

So keep an eye on it. FCP Groton once again has the gasket and seal kit listed but it is currently shown as backordered. You can still get everything ala carte now that they offer a gasket from Victor Reinz.
--
Any twenty minute job is just a broken bolt away from a three day ordeal






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New weeping leak of coolant on top of water pump,, [900][1993]
posted by  Blindboy subscriber  on Sat Jun 19 10:16 CST 2021 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.