Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 5/2005 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Electrical Problem 200

posted by  joericoh on  Sat Sep 3 05:27 CST 2005
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS] [RELATED]

I am betting this is not an alternator problem.
y daughter has a 85 240 that had the same problem. Mid 80s' had environmently friendly wiring insulation that breaks down over time and causes the wires to touch each other. If you look on the firewall ou will see a gray block that houses about six wires for the wiring harness. check the insulation on these wires(ours was crumbling) There are posts somewhere on this site on the way to deal with this. The wires that cause problems are the one to the alternator and the one to the oil pressure sending unit. We made a fix by bypassing the harness and rerouting new wires on the passenger side of the engine compartment. This is a cheap alternative to repalcing the entire wiring harness. Good luck and keeep us informed of what you find.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Electrical Problem [200]
posted by  dobber13 subscriber  on Thu Sep 1 14:05 CST 2005 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.