Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 5/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Hot temp gauge. Lots of diag. already performed. Need Volvo veteran diagnosis... 200 1989

uid 12839's pic
posted by  Paul Driver of Inga on  Fri May 28 01:36 CST 2010
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Sun Mar 25 16:42 CST 2012
[RELATED]

Sounds like you have done a very solid job of troubleshooting the problems and even gone above and beyond. I would be pulling hair myself if I had done all that.

About the only thing I don't see on the list and you may have already checked it is the fan clutch. You say you have a parts car, might be worth a few minutes with a 10mm wrench to swap it out and see if that does anything for you. I replaced Inga's fan clutch with a swamp cooler (AKA Tropical Fan Clutch) a couple of years ago and my temps dropped from 9:45-10:00 down to 9:00 right away and have stayed there. Might be a long shot but wanted to toss that out there.

If you want to eliminate the gauge, you can get a Vision VDO water temp gauge for $25 and the sending units run from $9 to $20 from egauges.com or Summit Racing. That is not a lot of money to put your mind at rest.

Just tossing stuff at the wall,

Good Luck and Regards,

Paul






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Hot temp gauge. Lots of diag. already performed. Need Volvo veteran diagnosis... [200][1989]
posted by  245DogWaggin  on Thu May 27 15:09 CST 2010 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.