Volvo AWD 850 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 9/2013 850 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

How to flush the tranny? 850

posted by  KlausC on  Mon Dec 20 16:06 CST 2010
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Fri Oct 24 10:15 CST 2014
[RELATED]

I went to the dealer and picked up a new spring clamp, the old one looked rusty. When I replaced the oil cooler lines, same clamps, I had 2 new clamps. Good thing because after removing the old clamps, they had lost their tension.

Caution when flushing: The fluid pumps out real fast. Turn the engine off when the fluid gets close to the 2 quart level. You do NOT want to pump fluid until you get bubbles, that intruduces air into the pump and stresses it.

Take your time pouring 2 quarts back in, it goes in very slowly, very, very slowly.

Do warm up the tranny with a 2 mile drive, you do not want the fluid too hot. You could melt the plastic milk jugs!

Klaus
--
Always willing to listen, just not able to take direction.






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New How to flush the tranny? [850]
posted by  B.B. subscriber  on Sun Dec 19 10:53 CST 2010 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.