Volvo RWD 444-544 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 7/2003 444-544 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE    PRINT   SAVE 

Rapping start up 444-544

posted by  jmenacker on  Thu Jan 19 05:14 CST 2006
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Wed Jan 21 09:31 CST 2009
[RELATED]

'66 122 stock B18D

At start up and during the first mile or so of driving there is a sharp rapping tone coming from the engine compartment. The rapping volume is directly proportional to work load. Tone stays about the same. After a mile or so the noise abates and does not return until the next cold start.

The noise is hard to locate but seems to be at the rear of the engine on the passenger side. No change after two different valve adjustment sessions.

The car is running _very_ well right now both for decent performance and good fuel economy (idles smooth, accellerates without hesitation, cruises for hours at 75 and gets close to 30 mpg).

Any guesses about the start up rapping (no, its not my neighbors 1000 watt stereo - that is a different issue) is appreciated. I suspect its an exhaust leak near the manifold. If so, how to check?

Joe M in WV






THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Rapping start up [444-544]
posted by  jmenacker subscriber  on Thu Jan 19 05:14 CST 2006 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.