Volvo RWD 200 Forum

INDEX FOR 1/2026(CURRENT) INDEX FOR 3/2004 200 INDEX

[<<]  [>>]


 VIEW    REPLY TO THIS MESSAGE Replies to this message will be emailed.    PRINT   SAVE 

Preemptive Starter Replacement 200

posted by  jwheli on  Wed Jul 6 15:26 CST 2011
Author: [PROFILE] [EVERY POST] [THREADS] [BEST POSTS] RSS Feed     [IGNORE ALL POSTS]
last visit: Wed Mar 12 11:19 CST 2014
[RELATED]

Interesting question.. I am not sure an actual life span, however, I just pulled mine last night on a 200169 mileage mark(240 1991). It was bad in the sense of a bearing issue and not the solenoid. Made an awful growling sound after the engine started. Seemed slow to turn as well but always started.

It was not the easiest job as I tried several tricks to move the transmission over, but ultimately dropped the transmission low enough to gain room to put on an 18mm socket, swivel, six inch extension and a three inch ext. Then an impact driver to get the top bolt out.

All in all, it was a rewarding job as the new one just pop into place and now it sounds like a full power starter engaging very well. I just hope I don't fall into a warranty issue and have to take it out again too soon!

Good Luck
JW





THREADED THREADED EXPANDED FLAT PRINT ALL
MESSAGES IN THIS THREAD

New Preemptive Starter Replacement [200]
posted by  MrNabisco  on Wed Jul 6 14:51 CST 2011 >


<< < > >>



©Jarrod Stenberg 1997-2022. All material except where indicated.


All participants agree to these terms.

Brickboard.com is not affiliated with nor sponsored by AB Volvo, Volvo Car Corporation, Volvo Cars of North America, Inc. or Ford Motor Company. Brickboard.com is a Volvo owner/enthusiast site, similar to a club, and does not intend to pose as an official Volvo site. The official Volvo site can be found here.